THE most well-known and perhaps the most beautiful of animal traps is the orb web constructed by certain spiders. Its design is remarkably precise and the materials with which it is made are amazingly strong. If pieces of man-made steel thread and spider silk of the same diameter were slowly loaded with increasing weight, the steel would snap first. Spider silk is five times stronger than steel. And not only that spider silk stretches; it can stretch twice as far as the equivalent strand of nylon. It is also produced rapidly and in large quantities. In a laboratory test, a spider produced a half-a-mile of thread in 10 minutes. An average orb web is completed, wind and weather permitting, in about half of hour.
The above qualities of spider silk have been attracting interest of specialists of various fields, besides designers. Actually, textile industry specialists first became interested in spiders more than 200 years ago, when people first tried to put a spiders web to some good use. They even wove it and made stockings and gloves for the French King Louis XIV. The same kind of gloves were presented to the wife of the German Emperor Carl VI. Some 65 years ago a special spider farm was set up in France to obtain spider silk (after all, if there are silk-worm farms, why not spider farms?). But the farm soon ceased to exist because it was impossible to feed these voracious creatures to do that dozens of farms growing flies and other insects would have to be set up nearby. Of course, getting their webs for fabrics was a very tempting proposition for they were stronger than steel and so light that a thread that could engirdle the globe would only weigh 350 grams.
|The orb web itself is suspended from a
single, horizontal, bridge strand. Below this, a
radiating pattern of threads join from the points in the
vegetation on the outside to a central hub at the centre
of the web. Immediately outside the hub are the
strengthening sections of closely spiralling threads, and
outside this part is the catching zone, consisting of a
spiral of sticky threads on which the prey is caught. The
droplets of sticky material are produced from a special
gland and daubed on to the threads at regular intervals.
The reflectivity of the sticky droplets is important. If they are too large and too many, they will reflect too much light and flying insects will be able to spot them and avoid the trap. The web must reflect as little light as possible, and the ideal droplet size, for a web in the open, is twice the diameter of the thread itself. Those spiders catching night-flying insects need to be less diligent. In the dark, they are able to use large droplets and so are able to catch moths that would normally escape a modestly sticky, day-type, web because they are able to shed wing scales and escape.
Spiders spinning very large webs, however, have major problems. How do they stop large creatures, such as birds, from flying into and tearing the web? Somehow they must make their webs invisible to insects yet visible to birds. They do this by weaving in a thickened band of silk, called stabilimenta, across the web. It is like a road sign that tells of an obstacle ahead. Birds flying towards an orb web have been seen to put their brakes on and fly over the top. By putting in the warning sign, the spider need not remake his web every day.
The net-throwing or
ogre-faced spider anchors its web at the ends of its
legs. By day, it stays hidden in a tree mimicking a twig,
but by night it spins an A-shaped frame of silk from
which it hangs, and constructs a net of the size of a
postage stamp which is attached to the feet of its front
four legs. When ready to capture prey, it hangs upside
down by its back four legs quite close to the ground. As
an insect passes beneath, it lunges down and stretches
the silken net over the victim, trapping it against the
ground. A poisonous bite dispatches the prey and the
spider sucks it dry.